International Journal of
Physical Sciences

  • Abbreviation: Int. J. Phys. Sci.
  • Language: English
  • ISSN: 1992-1950
  • DOI: 10.5897/IJPS
  • Start Year: 2006
  • Published Articles: 2557

Full Length Research Paper

Modification of plastic tank for bio-digestion of food wastes for biogas generation for cooking foods

Nwankwo, Chibuzo Stanley
  • Nwankwo, Chibuzo Stanley
  • Department of Food Science and Technology, College of Food and Human Ecology, Federal University of Agriculture, Makurdi, Nigeria.
  • Google Scholar
Okoyeuzu, Chigozie Francis
  • Okoyeuzu, Chigozie Francis
  • Department of Food Science and Technology, Faculty of Agriculture, University of Nigeria, Nsukka, Nigeria.
  • Google Scholar

  •  Received: 26 May 2020
  •  Accepted: 27 August 2020
  •  Published: 31 October 2020


The anaerobic states of the modified bio-digester and potentials of the generated biogas in cooking foods were evaluated. The study adopted experimental design. Data generated were analyzed using one - way analysis of variance and independent t-test. Carbon, free fatty acid, chemical and biochemical oxygen demand decreased significantly (p<0.05) while moisture and protein contents of the wastes increased significantly (p<0.05) after digestion. The 50% cow dung and 50% yam peel, and 50% cow dung and 50% vegetable had significantly (p<0.05) higher total (12.48%) and volatile (8.10%) solid contents respectively before digestion, but decreased significantly (p<0.05) after digestion. The pH of fermenting slurry was changing in line with the condition within the digester. Bacillus spp., Escherichia coli, klebsiella, Salmonella, Staphylococcus and Streptococcus were predominant microorganisms in all stages of biogas production from different wastes. Biogas generated from the wastes cooked significantly (p<0.05) faster than kerosene but not faster than liquefied petroleum gas. Cooking with biogas did not have any significant (p>0.05) effect on the proximate and sensory characteristics of foods when compared with the foods cooked with liquefied natural gas and kerosene.

Key words: Bio-degradation, food waste, cowdung, microorganisms, yam peel.



Biogas innovation offers an attractive platform for the creation of alternative source of energy if they are appropriately harnessed (Opeh and Okezie, 2011). Biogas is generated in the absence of oxygen by microorganisms in a process known as anaerobic digestion (Fang et al., 2010; Arsova, 2010). The conversion of organic matter into biogas is mainly by the action of different groups of microorganisms such as bacteria, fungi and protozoan. These microorganisms are classified into four groups such as hydrolytic, acidogenic (fermenting), acetogenic and methanogenic bacteria. They act on the different stages of the waste digestion  to bring about effective biogas production (Asikong et al., 2016). During hydrolysis, bacteria transform the organic substrate into monomers and polymers, such as proteins, carbohydrates and fatty acids. Acidogenesis involves further breakdown of the remaining components by acidogenic bacteria into short chain volatile fatty acids, ketones, alcohols, hydrogen and carbohydrate. The rest of the acidogenesis products are transformed by acetogenic bacteria into hydrogen, carbohydrate and acetic acid. Methanogenic microorganisms utilize intermediate products of these proceeding stages and convert them into methane,  carbohydrate and water. The major types of domestic anaerobic degradation system are the Chinese dome, Indian floating drum, Plug flow and the Puxin digesters (Jegede et al., 2019). They have no mechanical blenders and are unheated systems which make them cost effective and well appropriate for farmers and people living in rural areas. In sub-Sahara Africa especially Nigeria, domestic anaerobic degradation systems have had little success compared to Asia and Latin American countries due to inadequate technical application and social acknowledgment (Kalia, 2007). The realistic implementation of biogas innovation is in progress and has not acquired justifiable awareness (Opeh and Okezie, 2011). Furthermore, household digester fabricated from plastic for biogas generation from food wastes for cooking foods has not been adequately studied (Eze and Uzodinma, 2009; Nwankwo et al., 2017). Household digesters for biogas production from food wastes could be cost effective and eco-friendly energy substitute for cooking foods compared to other cooking fuel. However, this research focused on evaluating the anaerobic states of the modified bio-digester and potentials of the generated biogas in cooking foods compared to other cooking fuel.



Procurement of wastes

Kitchen wastes (yam peels and vegetable wastes) and cow dung were used for biogas production. The yam peels were collected in dried form from local yam fryers in Nsukka town, while vegetable waste was collected from restaurant located on the campus of the University of Nigeria, Nsukka. The cow dung was collected from the slaughter house at Nsukka Central abattoir.

Procedure for modification of plastic tank

The construction of the whole digester assembly involved different stages of work which include;

(i) Digester cover

(ii)  Agitator

(iii) Fermentation chamber

The digester cover was designed with hard foam material. The form material was tapered and rimmed with Lathe machine (Model C6241, make; Shanghai Changji, China) in such a way to cover the digester without biogas linkage. The digester cover was about 0.152 m in height, 0.023 m upper and 0.021 m lower diameters with a wood handle (0.04 m diameter and 0.111 m in height). The material used in designing the digester cover could withstand harsh environmental condition and could cover the digester in order to maintain anaerobic condition. The agitator (mass = 7.84 kg) was made of circle arms (0.24 m diameter each) joined  with iron steel rode of 0.61 m in length to enable the agitator to move to and fro freely. The iron steel joining the two circle arms was welded to a vertical iron rode of 1.22 m in length with two iron rods cross at the top (0.52 in length each). The two iron rods cross at the top of the vertical rode was to enable the agitation of the waste at the upper side of the digester. The center of vertical iron rode was welded to horizontal iron rode (0.73 m in length) which was welded to  another 45° bend iron rode (1.34 m in length) with a handle (0.24 m in length). The design of the agitator was such that a torque (𝜏) applied from the outside of the digester would be simply transmitted into the digester to agitate the system (Olaniyan et al., 2014). Owing to the toxic and corrosive nature of the waste inside the digester, it is necessary that the fermentation tank has good resistance to corrosion. As a result of the non-availability of right materials as well as the very expensive nature of the few available ones, PVC tank was used since it is cheap, durable and is able to resist corrosion. The slurry digester influent chamber was designed in such a way that it could be able to accommodate the agitator and the kitchen waste was able to go into the digester without blockage. The digester influent chamber was designed with 4” (0.11 m) PVC back nut, 4” (0.11 m) PVC male adepter, 4” (0.11 m) PVC 45° elbow bend and 4” (0.11 m) PVC pipe. The agitator handle was allowed to pass through the influent chamber. The effluent chamber was designed with 4” (0.11 m) PVC back nut, 4” (0.11 m) PVC male adapter and 4” (0.11 m) plastic ball valve such that all the slurry could be easily discharged after digestion (Figure 1). The materials and cost for the modification of plastic tank as the bio-degradation system is shown in Table 1.

Waste digestion and analysis

Three batches of experimental anaerobic bio-digestion were conducted for 28 days involving 50% cow dung and 50% yam peel and vegetable waste (WB1), 50% cow dung and 50% yam peel waste (WB2), and 50% cow dung and 50% vegetable waste (WB3). Each waste was weighed and diluted with water (1:3) and anaerobically digested in three different 3.6 m3 capacity plastic digester. The chemical characteristics and microbial analysis of the wastes were determined (AOAC, 2010). The pressure of the biogas produced was recorded daily with pressure gauge (model No.500 CE, make: Nagoya Aichi, Japan). Generated biogas from each waste was used to cook foods (yam and rice) thrice daily. Cooking time, proximate composition and sensory evaluation scores of foods cooked with generated biogas were compared to that of liquefied petroleum gas and kerosene (Iwe, 2002; Itodo et al., 2007).

Statistical analysis

The study adopted experimental design. Data generated were analyzed using one - way analysis of variance and independent t-test (p<0.05).


Chemical properties of wastes before and after digestion

The result in Table 2 shows the chemical properties of wastes before and after digestion. The total solid, volatile solid, carbon, free fatty acid, chemical and biochemical oxygen demand decreased significantly (p<0.05) while moisture and protein contents of the wastes increased significantly (p<0.05) after digestion. Comparable result was reported by Okunola et al. (2018) which was attributed to activities of microorganisms for biogas production. The wastes moisture content ranged from 75.07 to 80.88% before digestion but increased up to 84.76% after digestion. Yadav  et  al. (2014) reported that high moisture content in the waste will encourage movement and contact between microorganism and organic  molecules.  The   moisture  also  increased  after digestion due to decrease in the amount of volatile and total solid (Eze and Agbo, 2010a; Yadav et al., 2014). Decrease in carbohydrate, total solid and volatile soli was more significantly (p<0.05) in WB3 than others after digestion. This could be due to the production of organic acids (Yadav et al., 2014). The free fatty acids of wastes ranged from 0.06 to 0.10% and decreased significantly (p<0.05) after digestion. There was more significant (p<0.05) reduction in biochemical and chemical oxygen demand in WB1 than others after digestion may due to more   conversion    of    organic    matter    in    WB1    by microorganisms for biogas production (Utami et al., 2016).

Physical properties and volume of biogas production during waste digestion

The result in Table 3 shows that the ambient temperature ranges from 29 to 36°C and slurry temperature ranges from 31 oC to 37 oC during waste digestion. Slurry temperatures supported optimal biogas production because there was high biogas production as slurry temperature ranged from 31 oC to 37 oC. The pH of the three experimental wastes was fluctuating between 6.70 and 6.81. Fluctuation in pH may be due to higher acidogenesis and lower methanogenic activities, and vice vise (Beevi et al., 2013). Steady pH values were observed in waste WB3 (6.81) from 12th to 17th day and WB2 (6.75) from 12th to 14th day respectively. Steady pH values may be due to simultaneous acid production and also quick consumption of the acid by microorganisms for biogas production (Aragaw et al., 2013), Biogas production of WB1 increased gradually until it got to the 8th day (710 L); after which its biogas production began to fluctuate with highest biogas (712 L) production on the 20th day (Table 3). This might be attributed to a positive synergetic effect on the digestion of cow dung and food waste which provided more balanced nutrients (Aragaw et al., 2013). Just as in the volume of the biogas, the biogas pressure between 12th and 20th day was higher compared to other days, which was above 30 mmHg upto 36 mmHg in WB1. High pressure over 29-37 mmHg might affect the activities of methanogenic bacteria and biogas production (Dobre et al., 2014). Similar results were reported by Ebunilo et al. (2016) and Olorunmaiye et al. (2016) where the pressure fluctuation between 5 and 52 mmHg was recorded. The biogas production from WB2 and WB3 increased each day to the maximum on the 9th day (727 L) and on the 12 day (668 L) respectively, afterward biogas production began to fluctuate with corresponding biogas pressure between 10 and 36 mmHg. Similar result was reported by Aragaw et al. (2013) and Nwankwo et al. (2017). An increase in pressure may be as a result of increase in volume of biogas and temperature in the digester (Ebunilo et al., 2016; Olorunmaiye et al., 2016).

Microbial isolates and total viable count at different stages of waste digestion

The result in Table 4 shows that immediately after charging, total viable count of the three experimental wastes ranges from 2.42×108 to 3.82×107 cfu/ml and a total of eight morphologically and physiologically different bacteria species (Aspergillus nigar, Bacillus spp., Escherichia coli, Klebsiella, Salmonella, lactobacillus, Pseudomonas, Staphylococcus and Streptococcus) and two fungi species (Aspergillus spp and Sacchromyces) were also isolated. This might be attributed to the nature of the substrate (Ali Shah et al., 2014; Idire  et al., 2016). Immediately biogas production started, the total viable count increased significantly (p<0.05) while the isolated microorganisms reduced to six bacteria species. This may be due to the condition in the bio-degradation   system    was   thermo-dynamically unfavorable to the

microorganisms initial presence immediately after charging (Ali Shah et al., 2014) while significantly (p<0.05) increase immediately biogas production started mighty be due to high microbial populations involved in the hydrolytic and fermentative phases of biogas production. Comparable results were reported by Eze and Agbo (2010b) and Asikong et al. (2016). At the peak of biogas production, the total viable count was significantly (p<0.05) higher than the initial stage of biogas production with WB1 (5.81×108 cfu/ml) recording higher than others. This may be due to varying amount of different wastes.

The microbial loads and isolated microorganisms also decreased significantly (p<0.05) at the point of discharge. Similar result was reported by Asikong et al. (2016). This may be due to deposition of microbial metabolites and gradual exhaustion of nutrient from the wastes (Ziemiński and Frąc, 2012; Li et al., 2015; Asikong et al., 2016).

Effect of cooking with different heat sources on proximate composition and sensory characteristics of yam and rice

The result in Table 5 show that the biogas generated from different wastes cooked significantly (p<0.05) faster than kerosene but not faster than liquefied petroleum gas. Carbon dioxide and other gas (apart from methane) in biogas could reduce its cooking efficiency as reported by Eze (2012).

Abdulkareem (2005) concluded that refining biogas before using could improve its efficiency. In  terms  of  proximate  composition,  significantly (p<0.05) higher moisture content was recorded for yam and rice cooked with kerosene compared to other sources of heat may be due to  longer cooking time which allowed the foods to absorbed more water. The crude protein, fat, fibre, ash and carbohydrate contents were reduced insignificantly (p>0.05) in both yam and rice after cooking. Reduction in ash content could be that some soluble minerals dissolved in water during boiling (Assa et al., 2014). Significant (p>0.05) difference was  not  observed  in  sensory  characteristics  of yam and rice cooked with biogas, liquefied petroleum gas and kerosene (Table 6). Cooking with biogas did not affect the sensory characteristics of yam and rice differently when compared to liquefied petroleum gas and kerosene. It is quite difficult to pinpoint any of the heating sources as the best in terms of their effect on proximate and sensory characteristics of foods (Eze, 2012).



The significant (p<0.05) decrease in chemical properties such ash, fibre, fat, carbohydrate, total solid, volatile solid, carbon, free fatty acid, chemical and biochemical oxygen  demand after digestion and ability of bio-digesterto   generate   average  flammable  biogas  (0.574 m3per  day)  sufficient   to  cook  three   meals  per day  for  3  to 4 persons were an indication of high efficiency performance of the bio-digester. The microbial load increased significantly during biogas production and continued to increase significantly (p<0.05) at the peak of gas production and then reduced significantly (p<0.05) at the point of discharge. Bacillus spp., E. coli, klebsiella spp., Salmonella spp., Staphylococcus spp. and Streptococcus spp were predominant microorganisms in all stages of biogas production from  different  wastes. However,  considering  the fact that liquefied petroleum gas cooks significantly (p<0.05) faster than biogas, it is quite expensive for the average household in developing countries, especially Nigeria. Biogas can be an alternative cooking fuel in developing countries because it is cheaper and an environmental friendly. Moreover the cost and materials for fabricating the plastic bio-digester is cheap and durable. Finally, cooking with biogas as  observed   in   this   study   did   not  have  any significant (p>0.05) effect on the proximate composition and sensory characteristic of food when compared with the food cooked with liquefied petroleum gas and kerosene.


The authors have not declared any conflict of interests.


Abdulkareem AS (2005). Refining biogas produced from biomass: an alternative to cooking gas. Leonardo Journal of Science 7:1-8.


Ali Shah F, Mahmood Q, Maroof Shah M, Pervez A, Ahmad Asad S (2014). Microbial ecology of anaerobic digesters: the key players of anaerobiosis. The Scientific World Journal pp. 25-30.


Association of Official Analytical Chemists (AOAC) (2010). Official Methods of Analysis. 18th Edition, Revision 3, Association of Official Analytical Chemists, Washington DC.


Aragaw T, Andargie M, Gessesse A (2013). Co-digestion of cattle manure with organic kitchen waste to increase biogas production using rumen fluid as inoculums. International Journal of Physical Sciences 8(11):443-450.


Arsova L (2010). Anaerobic digestion of food waste: current status, problems and an alternative product. Department of Earth and Environmental Engineering foundation of Engineering and Applied Science Columbia University.


Asikong BE, Idire SO, Tiku DR (2016). Microorganisms associated with Biogas production using vegetable (Telfairia occidentalis) wastes, banana peel and pig dung as substrates. British Microbiology Research Journal 16(3):1-12.


Assa CD, Konan HK, Djè MK, Kouamé LP (2014). Effect of boiling time on some biochemical parameters of yam species (Dioscorea alata variety "Bètè-Bètè″) tubers. International Journal of Advanced Research 2(11):40-50


Beevi BS, Jose PP, Madhu G (2013). Effect of total solid concentration on anaerobic digestion of the organic fraction of municipal solid waste. International Journal of Scientific and Research Publications 3(8):1-5.


Dobre P, Nicolae FA, Matei F (2014). Main factors affecting biogas production - an overview. Romanian Biotechnological Letters 19(3):9283-9286.


Ebunilo PO, Ukwuaba SI, Owunna IB, Sadgere EG, Orhorhor EK (2016). Evaluation of cow dung and talinum triangulare as a seeding agent for the production of biogas from domestic wastes in warri metropolis. International Journal of Scientific and Engineering Research 7(3):633-641.


Eze JI, Agbo KE (2010). Studies on the microbial spectrum in anaerobic biomethannization of cow dung in 10 m3 fixed dome biogas digester. International Journal of the Physical Sciences 5(8):1331-1337.


Eze JI, Agbo KE (2010b). Maximizing the potentials of biogas through upgrading. American Journal of Scientific and Industrial Research 1(3):604-609.


Eze JI (2012). Nutritional and organoleptic properties of three common Nigerian foods cooked with three different energy sources. Scientific Research and Essays 7(22):2010-2016.


Eze JI, Uzodinma EO (2009). Generation of the methane gas from poultry brooding house. The Pacific Journal of Science and Technology 10(2):942-949.


Fang C, Angelidaki I, Boe K (2010). Biogas production from food-processing industrial wastes by anaerobic digestion. Ph.D Thesis, Technical University of Denmark (DTU).


Idire SO, Asikong BE, Tiku DR (2016). Potentials of banana peel, vegetable waste (Telfairia occidentalis) and pig dung substrates for biogas production. British Journal of Applied Science and Technology 16 (5):1-6.


Itodo IN, Agyo GE, Yusuf P (2007). Performance evaluation of a biogas stove for cooking in Nigeria. Journal of Energy in Southern Africa 18(3):14-18.


Iwe MO (2002). Handbook of sensory methods and analysis. PROJOINT Communications Services Ltd, Enugu pp. 70-72.


Jegede AO. Zeeman G, Bruning H (2019). A review of mixing, design and loading conditions in household anaerobic digesters. Journal Critical Review in Environmental Science and Technology 49(22):2117-2153.


Kalia VC (2007). Microbial treatment of domestic and industrial wastes for bioenergy production: In Applied Microbiology. Microbial Biotechnology and Genomics, Institute of Genomics and Integrative Biology, CSIR, Delhi University Campus, Mall Road, Delhi 110:7.


Li C, Moertelmaier C, Winter J, Gallert C (2015). Microbial community shifts during biogas production from biowaste and/or propionate. Bioengineering 2(1):35-53.


Nwankwo CS, Eze IJ, Okoyeuzu C, (2017). Design and fabrication of 3.60 m3 household plastic bio digester loaded with kitchen waste and cow dung for biogas generation. Scientific Research and Essays 12(14):130-141.


Okunola AA, Adewumi AD, Okonkwo CE, Kim PD, Okoro I, Ogunrinu SI, Osueke CO, and Idahosa EO (2018). Physico-Chemical Properties of Various Biomass Used in Anaerobic Digestion, International Journal of Civil Engineering and Technology 9(13):1403-1410.


Olaniyan AM, Sunmonu MO, Alabi KP (2014). Development of an anaerobic digestion unit for biogas production from cow dung substrate. Journal of Agricultural Science and Technology 4(9):743-749.


Olorunmaiye JA, Adegun IK, Aweda JO, Ajiboye TK, Abdulkareem S (2016). Effect of mixing ratio of cow dung, cassava peel and rice husk on thermodynamic properties of biogas in Anaerobic digester. iSTEAMS Multidisciplinary Conference Proceedings. University of professional studies, Accra Ghana Series 9:527-534.


Opeh R, Okezie U (2011). The significance of biogas plants in Nigeria's Energy strategy. Journal of Physic and Science Innovations 3:101-112.


Utami I, Redjeki S, Astuti DH (2016). Biogas production and removal COD-BOD and TSS from wastewater industrial alcohol (vinasse) by modified UASB bioreactor. In MATEC Web of Conferences (Vol. 58, P 01005). EDP Sciences.


Yadav N, Kumar R Rawat L, Gupta S (2014). Physico-chemical properties of before and after anaerobic digestion of Jatropha seed cake and mixed with pure cow dung. Journal of Chemical Engineering and Process Technology 5(2):186-190.


Ziemiński K, Frąc M (2012). Methane fermentation process as anaerobic digestion of biomass: Transformations, stages and microorganisms. African Journal of Biotechnology 11(18):4127-4139.